Memorial by Dutch artist Ruth Kupferschmidt for those killed and disabled by the 1984 toxic gas release
|Date||2 December 1984- 3 December 1984|
|Location||Bhopal, Madhya Pradesh, India|
|Also known as||Bhopal gas tragedy|
|Cause||Methyl Isocyanate leak from Union Carbide India Limited plant|
|Deaths||At least 3,787; over 16,000 claimed|
|Non-fatal injuries||At least 558,125|
The Bhopal disaster, also referred to as the Bhopal gas tragedy, was a gas leak incident on the night of 2-3 December 1984 at the Union Carbide India Limited (UCIL) pesticide plant in Bhopal, Madhya Pradesh, India. It was considered as of 2010 to be the world's worst industrial disaster.
Estimates vary on the death toll. The official immediate death toll was 2,259. The government of Madhya Pradesh confirmed a total of 3,787 deaths related to the gas release. A government affidavit in 2006 stated that the leak caused 558,125 injuries, including 38,478 temporary partial injuries and approximately 3,900 severely and permanently disabling injuries. Others estimate that 8,000 died within two weeks, and another 8,000 or more have since died from gas-related diseases.
The cause of the disaster remains under debate. The Indian government and local activists argue that slack management and deferred maintenance created a situation where routine pipe maintenance caused a backflow of water into a MIC tank, triggering the disaster. Union Carbide Corporation (UCC) contends water entered the tank through an act of sabotage.
The owner of the factory, UCIL, was majority owned by UCC, with Indian Government-controlled banks and the Indian public holding a 49.1 percent stake. In 1989, UCC paid $470 million ($907 million in 2014 dollars) to settle litigation stemming from the disaster. In 1994, UCC sold its stake in UCIL to Eveready Industries India Limited (EIIL), which subsequently merged with McLeod Russel (India) Ltd. Eveready ended clean-up on the site in 1998, when it terminated its 99-year lease and turned over control of the site to the state government of Madhya Pradesh. Dow Chemical Company purchased UCC in 2001, seventeen years after the disaster.
Civil and criminal cases were filed in the District Court of Bhopal, India, involving UCC and Warren Anderson, UCC CEO at the time of the disaster. In June 2010, seven former employees, including the former UCIL chairman, were convicted in Bhopal of causing death by negligence and sentenced to two years imprisonment and a fine of about $2,000 each, the maximum punishment allowed by Indian law. An eighth former employee was also convicted, but died before the judgement was passed. Anderson died on 29 September 2014.
The UCIL factory was built in 1969 to produce the pesticide Sevin (UCC's brand name for carbaryl) using methyl isocyanate (MIC) as an intermediate. An MIC production plant was added in 1979. After the Bhopal plant was built, other manufacturers, including Bayer, produced carbaryl without MIC, though at a greater manufacturing cost. Bayer also used the UCC process at the chemical plant once owned by UCC at Institute, West Virginia, in the United States.
The chemical process employed in the Bhopal plant had methylamine reacting with phosgene to form MIC, which was then reacted with 1-naphthol to form the final product, carbaryl. This "route" differed from the MIC-free routes used elsewhere, in which the same raw materials were combined in a different manufacturing order, with phosgene first reacting with naphthol to form a chloroformate ester, which was then reacted with methylamine. In the early 1980s, the demand for pesticides had fallen, but production continued, leading to build-up of stores of unused MIC.
In 1976, two local trade unions complained of pollution within the plant. In 1981, a worker was accidentally splashed with phosgene as he was carrying out a maintenance job of the plant's pipes. In a panic, he removed his gas mask and inhaled a large amount of toxic phosgene gas, leading to his death just 72 hours later. In January 1982, a phosgene leak exposed 24 workers, all of whom were admitted to a hospital. None of the workers had been ordered to wear protective masks. One month later, in February 1982, an MIC leak affected 18 workers. In August 1982, a chemical engineer came into contact with liquid MIC, resulting in burns over 30 percent of his body. Later that same year, in October 1982, there was another MIC leak. In attempting to stop the leak, the MIC supervisor suffered severe chemical burns and two other workers were severely exposed to the gases. During 1983 and 1984, there were leaks of MIC, chlorine, monomethylamine, phosgene, and carbon tetrachloride, sometimes in combination.
The Bhopal UCIL facility housed three underground 68,000 liters liquid MIC storage tanks: E610, E611, and E619. In the months leading up to the December leak, liquid MIC production was in progress and being used to fill these tanks. UCC safety regulations specified that no one tank should be filled more than 50% (here, 30 tons) with liquid MIC. Each tank was pressurized with inert nitrogen gas. This pressurization allowed liquid MIC to be pumped out of each tank as needed, and also kept impurities out of the tanks.
In late October 1984, tank E610 lost the ability to hold most of its nitrogen gas pressure. It meant that the liquid MIC contained within could not be pumped out. At the time of this failure, tank E610 contained 42 tons of liquid MIC. Shortly after this failure, MIC production was halted at the Bhopal facility, and parts of the plant were shut down for maintenance. Maintenance included the shutdown of the plant's flare tower so that a corroded pipe could be repaired. With the flare tower still out of service, production of carbaryl was resumed in late November, using MIC stored in the two tanks still in service. An attempt to re-establish pressure in tank E610 on 1 December failed, so the 42 tons of liquid MIC contained within still could not be pumped out of it.
In early December 1984, most of the plant's MIC related safety systems were not functioning and many valves and lines were in poor condition. In addition, several vent gas scrubbers had been out of service as well as the steam boiler, intended to clean the pipes. During the late evening hours of 2 December 1984, water was believed to have entered a side pipe and into Tank E610 whilst trying to unclog it, which contained 42 tons of MIC that had been there since late October. Introduction of water into the tank began a runaway exothermic reaction, which was accelerated by contaminants, high ambient temperatures and other factors, such as the presence of iron from corroding non-stainless steel pipelines. The pressure in tank E610, normal at 10:30 p.m., had increased by a factor of five to 10 psi (34.5 to 69 kPa) by 11 p.m. Two different senior refinery employees assumed the reading was instrumentation malfunction. By 11:30 p.m., workers in the MIC area were feeling the effects of minor exposure to MIC gas, and began to look for a leak. One was found by 11:45 p.m., and reported to the MIC supervisor on duty at the time. The decision was made to address the problem after a 12:15 a.m. tea break, and in the meantime, employees were instructed to continue looking for leaks. The leak was discussed by MIC area employees during the break.
In the five minutes after the tea break ended at 12:40 a.m., the reaction in tank E610 quickly reached a critical state. Temperatures in the tank were indicated off its scale, maxed out beyond 25 °C (77 °F), and the pressure in the tank was indicated at 40 psi (275.8 kPa). One employee witnessed a concrete slab above tank E610 crack as the emergency relief valve burst open, and pressure in the tank continued to increase to 55 psi (379.2 kPa) even after atmospheric venting of toxic MIC gas had begun. Direct atmospheric venting should have been prevented or at least partially mitigated by at least three safety devices which were not working properly, not in use, or insufficiently sized:
About 30 metric tons of MIC escaped from the tank into the atmosphere in 45 to 60 minutes. This would increase to 40 metric tons within two hours time. The gases were blown in a southeasterly direction over Bhopal.
A UCIL employee triggered the plant's alarm system at 12:50 a.m. as the concentration of gas in and around the plant became difficult to tolerate. Activation of the system triggered two siren alarms: one that sounded inside the UCIL plant, and a second directed outward to the public and the city of Bhopal. The two siren systems had been decoupled from one another in 1982, so that it was possible to leave the factory warning siren on while turning off the public one, and this is exactly what was done: the public siren briefly sounded at 12:50 a.m. and was quickly turned off, as per company procedure meant to avoid alarming the public around the factory over tiny leaks. Workers, meanwhile, evacuated the UCIL plant, travelling upwind.
Bhopal's superintendent of police was informed by telephone, by a town inspector, that residents of the neighbourhood of Chola (about 2 km from the plant) were fleeing a gas leak at approximately 1 a.m. Calls to the UCIL plant by police between 1:25 and 2:10 a.m. gave assurances twice that "everything is OK", and on the last attempt made, "we don't know what has happened, sir". With the lack of timely information exchange between UCIL and Bhopal authorities, the city's Hamidia Hospital was first told that the gas leak was suspected to be ammonia, then phosgene. They were then told that it was "MIC", which hospital staff had never heard of, had no antidote for, and received no immediate information about.
The MIC gas leak emanating from tank E610 petered out at approximately 2:00 a.m. Fifteen minutes later, the plant's public siren was sounded for an extended period of time, after first having been quickly silenced an hour and a half earlier. Some minutes after the public siren sounded, a UCIL employee walked to a police control room to both inform them of the leak (their first acknowledgement that one had occurred at all), and that "the leak had been plugged." Most city residents who were exposed to the MIC gas were first made aware of the leak by exposure to the gas itself, or by opening their doors to investigate commotion, rather than having been instructed to shelter in place, or to evacuate before the arrival of the gas in the first place.
The initial effects of exposure were coughing, severe eye irritation and a feeling of suffocation, burning in the respiratory tract, blepharospasm, breathlessness, stomach pains and vomiting. People awakened by these symptoms fled away from the plant. Those who ran inhaled more than those who had a vehicle to ride. Owing to their height, children and other people of shorter stature inhaled higher concentrations.
Thousands of people had died by the following morning.
Primary causes of deaths were choking, reflexogenic circulatory collapse and pulmonary oedema. Findings during autopsies revealed changes not only in the lungs but also cerebral oedema, tubular necrosis of the kidneys, fatty degeneration of the liver and necrotising enteritis. The stillbirth rate increased by up to 300% and neonatal mortality rate by around 200%.
Apart from MIC, based on laboratory simulation conditions, the gas cloud most likely also contained chloroform, dichloromethane, hydrogen chloride, methyl amine, dimethylamine, trimethylamine and carbon dioxide, that was either present in the tank or was produced in the storage tank when MIC, chloroform and water reacted. The gas cloud, composed mainly of materials denser than air, stayed close to the ground and spread in the southeasterly direction affecting the nearby communities. The chemical reactions may have produced a liquid or solid aerosol. Laboratory investigations by CSIR and UCC scientists failed to demonstrate the presence of hydrogen cyanide.
In the immediate aftermath, the plant was closed to outsiders (including UCC) by the Indian government, which subsequently failed to make data public, contributing to the confusion. The initial investigation was conducted entirely by the Council of Scientific and Industrial Research (CSIR) and the Central Bureau of Investigation. The UCC chairman and CEO Warren Anderson, together with a technical team, immediately traveled to India. Upon arrival Anderson was placed under house arrest and urged by the Indian government to leave the country within 24 hours. Union Carbide organized a team of international medical experts, as well as supplies and equipment, to work with the local Bhopal medical community, and the UCC technical team began assessing the cause of the gas leak.
The health care system immediately became overloaded. In the severely affected areas, nearly 70 percent were under-qualified doctors. Medical staff were unprepared for the thousands of casualties. Doctors and hospitals were not aware of proper treatment methods for MIC gas inhalation.:6
There were mass funerals and cremations. Photographer Pablo Bartholemew, on commission with press agency Rapho, took an iconic color photograph of a burial on December 4, Bhopal gas disaster girl. Another photographer present, Raghu Rai, took a black and white photo. The photographers did not ask for the identity of the father or child as she was buried, and no relative has since confirmed it. As such, the identity of the girl remains unknown. Both photos became symbolic of the suffering of victims of the Bhopal disaster, and Bartholomew's went on to win the 1984 World Press Photo of the Year.
Within a few days, trees in the vicinity became barren and bloated animal carcasses had to be disposed of. 170,000 people were treated at hospitals and temporary dispensaries; 2,000 buffalo, goats, and other animals were collected and buried. Supplies, including food, became scarce owing to suppliers' safety fears. Fishing was prohibited causing further supply shortages.
Lacking any safe alternative, on 16 December, tanks 611 and 619 were emptied of the remaining MIC by reactivating the plant and continuing the manufacture of pesticide. Despite safety precautions such as having water carrying helicopters continually overflying the plant, this led to a second mass evacuation from Bhopal. The Government of India passed the "Bhopal Gas Leak Disaster Act" that gave the government rights to represent all victims, whether or not in India. Complaints of lack of information or misinformation were widespread. An Indian government spokesman said, "Carbide is more interested in getting information from us than in helping our relief work".
Formal statements were issued that air, water, vegetation and foodstuffs were safe, but warned not to consume fish. The number of children exposed to the gases was at least 200,000. Within weeks, the State Government established a number of hospitals, clinics and mobile units in the gas-affected area to treat the victims.
Legal proceedings involving UCC, the United States and Indian governments, local Bhopal authorities, and the disaster victims started immediately after the catastrophe. The Indian Government passed the Bhopal Gas Leak Act in March 1985, allowing the Government of India to act as the legal representative for victims of the disaster, leading to the beginning of legal proceedings. Initial lawsuits were generated in the United States federal court system. On April 17, 1985, Federal District court judge John F. Keenan (overseeing one lawsuit) suggested that "'fundamental human decency' required Union Carbide to provide between $5 million and $10 million to immediately help the injured" and suggested the money could be quickly distributed through the International Red Cross. UCC, on the notion that doing so did not constitute an admission of liability and the figure could be credited toward any future settlement or judgement, offered a $5 million relief fund two days later. The Indian government turned down the offer.
In March 1986 UCC proposed a settlement figure, endorsed by plaintiffs' U.S. attorneys, of that would, according to the company, "generate a fund for Bhopal victims of between over 20 years". In May, litigation was transferred from the United States to Indian courts by a U.S. District Court ruling. Following an appeal of this decision, the U.S. Court of Appeals affirmed the transfer, judging, in January 1987, that UCIL was a "separate entity, owned, managed and operated exclusively by Indian citizens in India".
The Government of India refused the offer from Union Carbide and claimed US$. The Indian Supreme Court told both sides to come to an agreement and "start with a clean slate" in November 1988. Eventually, in an out-of-court settlement reached in February 1989, Union Carbide agreed to pay US$ for damages caused in the Bhopal disaster. The amount was immediately paid.
Throughout 1990, the Indian Supreme Court heard appeals against the settlement. In October 1991, the Supreme Court upheld the original , dismissing any other outstanding petitions that challenged the original decision. The Court ordered the Indian government "to purchase, out of settlement fund, a group medical insurance policy to cover 100,000 persons who may later develop symptoms" and cover any shortfall in the settlement fund. It also requested UCC and its subsidiary UCIL "voluntarily" fund a hospital in Bhopal, at an estimated , to specifically treat victims of the Bhopal disaster. The company agreed to this.
In 1991, the local Bhopal authorities charged Anderson, who had retired in 1986, with manslaughter, a crime that carries a maximum penalty of 10 years in prison. He was declared a fugitive from justice by the Chief Judicial Magistrate of Bhopal on 1 February 1992 for failing to appear at the court hearings in a culpable homicide case in which he was named the chief defendant. Orders were passed to the Government of India to press for an extradition from the United States. The U.S. Supreme Court refused to hear an appeal of the decision of the lower federal courts in October 1993, meaning that victims of the Bhopal disaster could not seek damages in a U.S. court.
In 2004, the Indian Supreme Court ordered the Indian government to release any remaining settlement funds to victims. And in September 2006, the Welfare Commission for Bhopal Gas Victims announced that all original compensation claims and revised petitions had been "cleared". The Second Circuit Court of Appeals in New York City upheld the dismissal of remaining claims in the case of Bano v. Union Carbide Corporation in 2006. This move blocked plaintiffs' motions for class certification and claims for property damages and remediation. In the view of UCC, "the ruling reaffirms UCC's long-held positions and finally puts to rest--both procedurally and substantively--the issues raised in the class action complaint first filed against Union Carbide in 1999 by Haseena Bi and several organisations representing the residents of Bhopal".
In June 2010, seven former employees of UCIL, all Indian nationals and many in their 70s, were convicted of causing death by negligence: Keshub Mahindra, former non-executive chairman of Union Carbide India Limited; V. P. Gokhale, managing director; Kishore Kamdar, vice-president; J. Mukund, works manager; S. P. Chowdhury, production manager; K. V. Shetty, plant superintendent; and S. I. Qureshi, production assistant. They were each sentenced to two years imprisonment and fined Rs.100,000 (US$2,124). All were released on bail shortly after the verdict.
US Federal class action litigation, Sahu v. Union Carbide and Warren Anderson, had been filed in 1999 under the U.S. Alien Torts Claims Act (ATCA), which provides for civil remedies for "crimes against humanity." It sought damages for personal injury, medical monitoring and injunctive relief in the form of clean-up of the drinking water supplies for residential areas near the Bhopal plant. The lawsuit was dismissed in 2012 and subsequent appeal denied. Anderson died in 2014.
A total of 36 wards were marked by the authorities as being "gas affected," affecting a population of 520,000. Of these, 200,000 were below 15 years of age, and 3,000 were pregnant women. The official immediate death toll was 2,259, and in 1991, 3,928 deaths had been officially certified. Ingrid Eckerman estimated 8,000 died within two weeks.
Later, the affected area was expanded to include 700,000 citizens. A government affidavit in 2006 stated the leak caused 558,125 injuries including 38,478 temporary partial injuries and approximately 3,900 severely and permanently disabling injuries.
A cohort of 80,021 exposed people was registered, along with a control group, a cohort of 15,931 people from areas not exposed to MIC. Nearly every year since 1986, they have answered the same questionnaire. It shows overmortality and overmorbidity in the exposed group. Bias and confounding factors cannot be excluded from the study. Because of migration and other factors, 75% of the cohort is lost, as the ones who moved out are not followed.
A number of clinical studies are performed. The quality varies, but the different reports support each other. Studied and reported long term health effects are:
Missing or insufficient fields for research are female reproduction, chromosomal aberrations, cancer, immune deficiency, neurological sequelae, post traumatic stress disorder (PTSD) and children born after the disaster. Late cases that might never be highlighted are respiratory insufficiency, cardiac insufficiency (cor pulmonale), cancer and tuberculosis.
A 2014 report in Mother Jones quotes a "spokesperson for the Bhopal Medical Appeal, which runs free health clinics for survivors" as saying "An estimated 120,000 to 150,000 survivors still struggle with serious medical conditions including nerve damage, growth problems, gynecological disorders, respiratory issues, birth defects, and elevated rates of cancer and tuberculosis."
The Government of India had focused primarily on increasing the hospital-based services for gas victims thus hospitals had been built after the disaster. When UCC wanted to sell its shares in UCIL, it was directed by the Supreme Court to finance a 500-bed hospital for the medical care of the survivors. Thus, Bhopal Memorial Hospital and Research Centre (BMHRC) was inaugurated in 1998 and was obliged to give free care for survivors for eight years. BMHRC was a 350-bedded super speciality hospital where heart surgery and hemodialysis were done. There was a dearth of gynaecology, obstetrics and paediatrics. Eight mini-units (outreach health centres) were started and free health care for gas victims were to be offered till 2006. The management had also faced problems with strikes, and the quality of the health care being disputed.Sambhavna Trust is a charitable trust, registered in 1995, that gives modern as well as ayurvedic treatments to gas victims, free of charge.
When the factory was closed in 1986, pipes, drums and tanks were sold. The MIC and the Sevin plants are still there, as are storages of different residues. Isolation material is falling down and spreading. The area around the plant was used as a dumping area for hazardous chemicals. In 1982 tubewells in the vicinity of the UCIL factory had to be abandoned and tests in 1989 performed by UCC's laboratory revealed that soil and water samples collected from near the factory and inside the plant were toxic to fish. Several other studies had also shown polluted soil and groundwater in the area. Reported polluting compounds include 1-naphthol, naphthalene, Sevin, tarry residue, mercury, toxic organochlorines, volatile organochlorine compounds, chromium, copper, nickel, lead, hexachloroethane, hexachlorobutadiene, and the pesticide HCH.
In order to provide safe drinking water to the population around the UCIL factory, Government of Madhya Pradesh presented a scheme for improvement of water supply. In December 2008, the Madhya Pradesh High Court decided that the toxic waste should be incinerated at Ankleshwar in Gujarat, which was met by protests from activists all over India. On 8 June 2012, the Centre for incineration of toxic Bhopal waste agreed to pay (US$3.8 million) to dispose of UCIL chemical plants waste in Germany. On 9 August 2012, Supreme court directed the Union and Madhya Pradesh Governments to take immediate steps for disposal of toxic waste lying around and inside the factory within six months.
A U.S. court rejected the lawsuit blaming UCC for causing soil and water pollution around the site of the plant and ruled that responsibility for remedial measures or related claims rested with the State Government and not with UCC. In 2005, the state government invited various Indian architects to enter their "concept for development of a memorial complex for Bhopal gas tragedy victims at the site of Union Carbide". In 2011, a conference was held on the site, with participants from European universities which was aimed for the same.
33 of the 50 planned work-sheds for gas victims started. All except one was closed down by 1992. 1986, the MP government invested in the Special Industrial Area Bhopal. 152 of the planned 200 work sheds were built and in 2000, 16 were partially functioning. It was estimated that 50,000 persons need alternative jobs, and that less than 100 gas victims had found regular employment under the government's scheme. The government also planned 2,486 flats in two- and four-story buildings in what is called the "widow's colony" outside Bhopal. The water did not reach the upper floors and it was not possible to keep cattle which were their primary occupation. Infrastructure like buses, schools, etc. were missing for at least a decade.
Immediate relieves were decided two days after the tragedy. Relief measures commenced in 1985 when food was distributed for a short period along with ration cards.Madhya Pradesh government's finance department allocated (US$13 million) for victim relief in July 1985. Widow pension of (US$3.10)/per month (later (US$11)) were provided. The government also decided to pay (US$23) to families with monthly income (US$7.70) or less. As a result of the interim relief, more children were able to attend school, more money was spent on treatment and food, and housing also eventually improved. From 1990 interim relief of (US$3.10) was paid to everyone in the family who was born before the disaster.
The final compensation, including interim relief for personal injury was for the majority (US$380). For death claim, the average sum paid out was (US$950). Each claimant were to be categorised by a doctor. In court, the claimants were expected to prove "beyond reasonable doubt" that death or injury in each case was attributable to exposure. In 1992, 44 percent of the claimants still had to be medically examined.
By the end of October 2003, according to the Bhopal Gas Tragedy Relief and Rehabilitation Department, compensation had been awarded to 554,895 people for injuries received and 15,310 survivors of those killed. The average amount to families of the dead was $2,200.
In 2007, 1,029,517 cases were registered and decided. Number of awarded cases were 574,304 and number of rejected cases 455,213. Total compensation awarded was (US$240 million). On 24 June 2010, the Union Cabinet of the Government of India approved a (US$190 million) aid package which would be funded by Indian taxpayers through the government.
In 1985, Henry Waxman, a California Democrat, called for a U.S. government inquiry into the Bhopal disaster, which resulted in U.S. legislation regarding the accidental release of toxic chemicals in the United States.
There are two main lines of argument involving the disaster. The "Corporate Negligence" point of view argues that the disaster was caused by a potent combination of under-maintained and decaying facilities, a weak attitude towards safety, and an undertrained workforce, culminating in worker actions that inadvertently enabled water to penetrate the MIC tanks in the absence of properly working safeguards.
The "Worker Sabotage" point of view argues that it was not physically possible for the water to enter the tank without concerted human effort, and that extensive testimony and engineering analysis leads to a conclusion that water entered the tank when a rogue individual employee hooked a water hose directly to an empty valve on the side of the tank. This point of view further argues that the Indian government took extensive actions to hide this possibility in order to attach blame to UCC.
Theories differ as to how the water entered the tank. At the time, workers were cleaning out a clogged pipe with water about 400 feet from the tank. They claimed that they were not told to isolate the tank with a pipe slip-blind plate. The operators assumed that owing to bad maintenance and leaking valves, it was possible for the water to leak into the tank.
This water entry route could not be reproduced despite strenuous efforts by motivated parties. UCC claims that a "disgruntled worker" deliberately connecting a hose to a pressure gauge connection was the real cause.
Early the next morning, a UCIL manager asked the instrument engineer to replace the gauge. UCIL's investigation team found no evidence of the necessary connection; the investigation was totally controlled by the government, denying UCC investigators access to the tank or interviews with the operators.
This point of view argues that management (and to some extent, local government) underinvested in safety, which allowed for a dangerous working environment to develop. Factors cited include the filling of the MIC tanks beyond recommended levels, poor maintenance after the plant ceased MIC production at the end of 1984, allowing several safety systems to be inoperable due to poor maintenance, and switching off safety systems to save money-- including the MIC tank refrigeration system which could have mitigated the disaster severity, and non-existent catastrophe management plans. Other factors identified by government inquiries included undersized safety devices and the dependence on manual operations. Specific plant management deficiencies that were identified include the lack of skilled operators, reduction of safety management, insufficient maintenance, and inadequate emergency action plans.
Underinvestment is cited as contributing to an environment. Attempts to reduce expenses affected the factory's employees and their conditions. Kurzman argues that "cuts ... meant less stringent quality control and thus looser safety rules. A pipe leaked? Don't replace it, employees said they were told ... MIC workers needed more training? They could do with less. Promotions were halted, seriously affecting employee morale and driving some of the most skilled ... elsewhere". Workers were forced to use English manuals, even though only a few had a grasp of the language.
Subsequent research highlights a gradual deterioration of safety practices in regard to the MIC, which had become less relevant to plant operations. By 1984, only six of the original twelve operators were still working with MIC and the number of supervisory personnel had also been halved. No maintenance supervisor was placed on the night shift and instrument readings were taken every two hours, rather than the previous and required one-hour readings. Workers made complaints about the cuts through their union but were ignored. One employee was fired after going on a 15-day hunger strike. 70% of the plant's employees were fined before the disaster for refusing to deviate from the proper safety regulations under pressure from the management.
In addition, some observers, such as those writing in the Trade Environmental Database (TED) Case Studies as part of the Mandala Project from American University, have pointed to "serious communication problems and management gaps between Union Carbide and its Indian operation", characterised by "the parent companies [sic] hands-off approach to its overseas operation" and "cross-cultural barriers".
Adequacy of equipment and safety regulations
The factory was not well equipped to handle the gas created by the sudden addition of water to the MIC tank. The MIC tank alarms had not been working for four years and there was only one manual back-up system, compared to a four-stage system used in the United States. The flare tower and several vent gas scrubbers had been out of service for five months before the disaster. Only one gas scrubber was operating: it could not treat such a large amount of MIC with sodium hydroxide (caustic soda), which would have brought the concentration down to a safe level. The flare tower could only handle a quarter of the gas that leaked in 1984, and moreover it was out of order at the time of the incident. To reduce energy costs, the refrigeration system was idle. The MIC was kept at 20 degrees Celsius, not the 4.5 degrees advised by the manual. Even the steam boiler, intended to clean the pipes, was non-operational for unknown reasons. Slip-blind plates that would have prevented water from pipes being cleaned from leaking into the MIC tanks, had the valves been faulty, were not installed and their installation had been omitted from the cleaning checklist. As MIC is water-soluble, deluge guns were in place to contain escaping gases from the stack. The water pressure was too weak for the guns to spray high enough to reach the gas which would have reduced the concentration of escaping gas significantly. In addition to it, carbon steel valves were used at the factory, even though they were known to corrode when exposed to acid.
According to the operators, the MIC tank pressure gauge had been malfunctioning for roughly a week. Other tanks were used, rather than repairing the gauge. The build-up in temperature and pressure is believed to have affected the magnitude of the gas release. UCC admitted in their own investigation report that most of the safety systems were not functioning on the night of 3 December 1984. The design of the MIC plant, following government guidelines, was "Indianized" by UCIL engineers to maximise the use of indigenous materials and products. Mumbai-based Humphreys and Glasgow Consultants Pvt. Ltd., were the main consultants, Larsen & Toubro fabricated the MIC storage tanks, and Taylor of India Ltd. provided the instrumentation. In 1998, during civil action suits in India, it emerged that the plant was not prepared for problems. No action plans had been established to cope with incidents of this magnitude. This included not informing local authorities of the quantities or dangers of chemicals used and manufactured at Bhopal.
Safety audits were done every year in the US and European UCC plants, but only every two years in other parts of the world. Before a "Business Confidential" safety audit by UCC in May 1982, the senior officials of the corporation were well aware of "a total of 61 hazards, 30 of them major and 11 minor in the dangerous phosgene/methyl isocyanate units" in Bhopal. In the audit 1982, it was indicated that worker performance was below standards. Ten major concerns were listed. UCIL prepared an action plan, but UCC never sent a follow-up team to Bhopal. Many of the items in the 1982 report were temporarily fixed, but by 1984, conditions had again deteriorated. In September 1984, an internal UCC report on the West Virginia plant in the USA revealed a number of defects and malfunctions. It warned that "a runaway reaction could occur in the MIC unit storage tanks, and that the planned response would not be timely or effective enough to prevent catastrophic failure of the tanks". This report was never forwarded to the Bhopal plant, although the main design was the same.
Now owned by Dow Chemical Company, Union Carbide maintains a website dedicated to the tragedy and claims that the incident was the result of sabotage, stating that sufficient safety systems were in place and operative to prevent the intrusion of water.
The impossibility of the "negligence" argument
According to the "Corporate Negligence" argument, workers had been cleaning out pipes with water nearby. This water was diverted due to a combination of improper maintenance, leaking and clogging, and eventually ended up in the MIC storage tank. Indian scientists also suggested that additional water might have been introduced as a "back-flow" from a defectively designed vent-gas scrubber. None of these theoretical routes of entry were ever successfully demonstrated during tests by the Central Bureau of Investigators (CBI) and UCIL engineers.
The Union Carbide commissioned Arthur D. Little report concludes that it is likely that a single employee secretly and deliberately introduced a large amount of water into the MIC tank by removing a meter and connecting a water hose directly to the tank through the metering port.
UCC claims the plant staff falsified numerous records to distance themselves from the incident and absolve themselves of blame, and that the Indian Government impeded its investigation and declined to prosecute the employee responsible, presumably because that would weaken its allegations of negligence by Union Carbide.
The evidence in favor of this point of view includes:
The Little report argues that this evidence demonstrates that the following chronology took place:
The theory of design defect was floated by the central government in its endeavour to do justice to the victims of the tragedy. Everyone else who was part of investigations into the case "just toed the line of the central government.... The government and the CBI suppressed the actual truth and saved the real perpetrators of the crime, the counsel, Anirban Roy told the court."
In November 2017, appearing for two accused S P Chaudhary and J Mukund, their advocate Anirban Roy told the district court on Monday that disgruntled plant operator M L Verma was behind the sabotage because he was unhappy with his seniors. Roy argued that the theory about defects in the plant causing the mishap was imaginary. He said truth had always been suppressed and it's for the CBI to bring it out. The counsel argued that there were discrepancies in the statements given by persons who were operating the plant at that time but the central agency chose not to investigate the case properly because it always wanted to prove that it was a mishap, and not sabotage. He alleged that Verma was unhappy with Chaudhary and Mukund. 
The corporation denied the claim that the valves on the tank were malfunctioning, and claimed that the documented evidence gathered after the incident showed that the valve close to the plant's water-washing operation was closed and was leak-tight. Furthermore, process safety systems had prevented water from entering the tank by accident. Carbide states that the safety concerns identified in 1982 were all allayed before 1984 and had nothing to do with the incident.
The company admitted that the safety systems in place would not have been able to prevent a chemical reaction of that magnitude from causing a leak. According to Carbide, "in designing the plant's safety systems, a chemical reaction of this magnitude was not factored in" because "the tank's gas storage system was designed to automatically prevent such a large amount of water from being inadvertently introduced into the system" and "process safety systems--in place and operational--would have prevented water from entering the tank by accident". Instead, they claim that "employee sabotage--not faulty design or operation--was the cause of the tragedy".
The company stresses the immediate action taken after the disaster and its continued commitment to helping the victims. On 4 December, the day following the leak, Union Carbide sent material aid and several international medical experts to assist the medical facilities in Bhopal.
The primary financial restitution paid by UCC was negotiated in 1989, when the Indian Supreme Court approved a settlement of US$470 million ( (equivalent to INR80 billion or US$1.2 billion in 2017)). This amount was immediately paid by UCC to the Indian government. The company states that the restitution paid "was $120 million more than plaintiffs' lawyers had told U.S. courts was fair" and that the Indian Supreme Court stated in its opinion that "compensation levels under the settlement were far greater than would normally be payable under Indian law."
In the immediate aftermath of the disaster, Union Carbide states on its website that it put $2 million into the Indian prime minister's immediate disaster relief fund on 11 December 1984. The corporation established the Employees' Bhopal Relief Fund in February 1985, which raised more than for immediate relief. According to Union Carbide, in August 1987, they made an additional in humanitarian interim relief available.
Union Carbide stated that it also undertook several steps to provide continuing aid to the victims of the Bhopal disaster. The sale of its 50.9 percent interest in UCIL in April 1992 and establishment of a charitable trust to contribute to the building of a local hospital. The sale was finalised in November 1994. The hospital was begun in October 1995 and was opened in 2001. The company provided a fund with around from sale of its UCIL stock. In 1991, the trust had amounted approximately . The hospital catered for the treatment of heart, lung and eye problems. UCC also provided a $2.2 million grant to Arizona State University to establish a vocational-technical center in Bhopal, which was opened, but was later closed by the state government. They also donated $5 million to the Indian Red Cross after the disaster. They also developed a Responsible Care system with other members of the chemical industry as a response to the Bhopal crisis, which was designed to help prevent such an event in the future.
UCC chairman and CEO Warren Anderson was arrested and released on bail by the Madhya Pradesh Police in Bhopal on 7 December 1984. Anderson was taken to UCC's house after which he was released six hours later on $2,100 bail and flown out on a government plane. These actions were allegedly taken under the direction of then chief secretary of the state, who was possibly instructed from chief minister's office, who himself flew out of Bhopal immediately. Later in 1987, the Indian government summoned Anderson, eight other executives and two company affiliates with homicide charges to appear in Indian court. In response, Union Carbide said the company is not under Indian jurisdiction.
From 2014, Dow is a named respondent in a number of ongoing cases arising from Union Carbide's business in Bhopal.
Chemicals abandoned at the plant continue to leak and pollute the groundwater. Whether the chemicals pose a health hazard is disputed. Contamination at the site and surrounding area was not caused by the gas leakage. The area around the plant was used as a dumping ground for hazardous chemicals and by 1982 water wells in the vicinity of the UCIL factory had to be abandoned. UCC states that "after the incident, UCIL began clean-up work at the site under the direction of Indian central and state government authorities", which was continued after 1994 by the successor to UCIL. The successor, Eveready Industries India, Limited (EIIL), ended cleanup on the site in 1998, when it terminated its 99-year lease and turned over control of the site to the state government of Madhya Pradesh.
UCC's laboratory tests in 1989 revealed that soil and water samples collected from near the factory were toxic to fish. Twenty-one areas inside the plant were reported to be highly polluted. In 1991 the municipal authorities declared that water from over 100 wells was hazardous for health if used for drinking. In 1994 it was reported that 21% of the factory premises were seriously contaminated with chemicals. Beginning in 1999, studies made by Greenpeace and others from soil, groundwater, well water and vegetables from the residential areas around UCIL and from the UCIL factory area show contamination with a range of toxic heavy metals and chemical compounds. Substances found, according to the reports, are naphthol, naphthalene, Sevin, tarry residues, alpha naphthol, mercury, organochlorines, chromium, copper, nickel, lead, hexachlorethane, hexachlorobutadiene, pesticide HCH (BHC), volatile organic compounds and halo-organics. Many of these contaminants were also found in breast milk of women living near the area. Soil tests were conducted by Greenpeace in 1999. One sample (IT9012) from "sediment collected from drain under former Sevin plant" showed mercury levels to be at "20,000 and times" higher than expected levels. Organochlorine compounds at elevated levels were also present in groundwater collected from (sample IT9040) a 4.4 meter depth "bore-hole within the former UCIL site". This sample was obtained from a source posted with a warning sign which read "Water unfit for consumption". Chemicals that have been linked to various forms of cancer were also discovered, as well as trichloroethylene, known to impair fetal development, at 50 times above safety limits specified by the U.S. Environmental Protection Agency (EPA). In 2002, an inquiry by Fact-Finding Mission on Bhopal found a number of toxins, including mercury, lead, 1,3,5 trichlorobenzene, dichloromethane and chloroform, in nursing women's breast milk.
A 2004 BBC Radio 5 broadcast reported the site is contaminated with toxic chemicals including benzene hexachloride and mercury, held in open containers or loose on the ground. A drinking water sample from a well near the site had levels of contamination 500 times higher than the maximum limits recommended by the World Health Organization. In 2009, the Centre for Science and Environment, a Delhi-based pollution monitoring lab, released test results showing pesticide groundwater contamination up to three kilometres from the factory. Also in 2009, the BBC took a water sample from a frequently used hand pump, located just north of the plant. The sample, tested in UK, was found to contain 1,000 times the World Health Organization's recommended maximum amount of carbon tetrachloride, a carcinogenic toxin.
In 2010, a British photojournalist who ventured into the abandoned Union Carbide factory to investigate allegations of abandoned, leaking toxins, was hospitalized in Bhopal for a week after he was exposed to the chemicals. Doctors at the Sambhavna Clinic treated him with oxygen, painkillers and anti-inflammatories following a severe respiratory reaction to toxic dust inside the factory.
In October 2011, the Institute of Environmental Management and Assessment published an article and video by two British environmental scientists, showing the current state of the plant, landfill and solar evaporation ponds and calling for renewed international efforts to provide the necessary skills to clean up the site and contaminated groundwater.
Amulya Malladi's 2002 novel A Breath of Fresh Air relates the story of a mother and son who develop health issues as a result of exposure to gas at Bhopal. The book is based on Malladi's recollections of Bhopal during the incident.
In 2014, to coincide with the 30th anniversary of the disaster, historical-drama Bhopal: A Prayer for Rain was released, starring Martin Sheen as Union Carbide CEO Warren Anderson, Kal Penn, and Mischa Barton. The film earned global praise and LA Times critic Martin Tsai said the film was "ambitious and shattering" and that "Although the real-life events took place three decades ago, the cautionary tale could not be more relevant."
Arundhati Roy's 2017 novel The Ministry of Utmost Happiness which deals with many contemporary political issues in India also features several characters dealing with the aftermath of the gas leak still.
Since 1984, individual activists have played a role in the aftermath of the tragedy. The best-known is Satinath Sarangi (Sathyu), a metallurgic engineer who arrived at Bhopal the day after the leakage. He founded several activist groups, as well as Sambhavna Trust, the clinic for gas affected patients, where he is the manager. Other activists include Rashida Bee and Champa Devi Shukla, who received the Goldman Prize in 2004, Abdul Jabbar and Rachna Dhingra.
Soon after the accident, representatives from different activist groups arrived. The activists worked on organising the gas victims, which led to violent repression from the police and the government.
Numerous actions have been performed: demonstrations, sit-ins, hunger strikes, marches combined with pamphlets, books, and articles. Every anniversary, actions are performed. Often these include marches around Old Bhopal, ending with burning an effigy of Warren Anderson.
In 1994, the International Medical Commission on Bhopal (IMCB) met in Bhopal. Their work contributed to long term health effects being officially recognised.
Important international actions have been the tour to Europe and United States in 2003, the marches to Delhi in 2006 and 2008, all including hunger strikes, and the Bhopal Europe Bus Tour in 2009.
Around ten local organisations, engaged on long term, have been identified. Two of the most active organisations are the women's organisations--Bhopal Gas Peedit Mahila-Stationery Karmachari Sangh and Bhopal Gas Peedit Mahila Udyog Sangthan.
More than 15 national organisations have been engaged along with a number of international organisations.
Some of the most important organisations are:
On 3 December 2004, the twentieth anniversary of the disaster, a man falsely claiming to be a Dow representative named Jude Finisterra was interviewed on BBC World News. He claimed that the company had agreed to clean up the site and compensate those harmed in the incident, by liquidating Union Carbide for . Dow quickly issued a statement saying that they had no employee by that name--that he was an impostor, not affiliated with Dow, and that his claims were a hoax. The BBC later broadcast a correction and an apology.
Jude Finisterra was actually Andy Bichlbaum, a member of the activist prankster group The Yes Men. In 2002, The Yes Men issued a fake press release explaining why Dow refused to take responsibility for the disaster and started up a website, at "DowEthics.com", designed to look like the real Dow website, but containing hoax information.
The release of an email cache related to intelligence research organisation Stratfor was leaked by WikiLeaks on 27 February 2012. It revealed that Dow Chemical had engaged Stratfor to spy on the public and personal lives of activists involved in the Bhopal disaster, including the Yes Men. E-mails to Dow representatives from hired security analysts list the YouTube videos liked, Twitter and Facebook posts made and the public appearances of these activists. Journalists, film-makers and authors who were investigating Bhopal and covering the issue of ongoing contamination, such as Jack Laurenson and Max Carlson, were also placed under surveillance. Stratfor released a statement condemning the revelation by Wikileaks while neither confirming nor denying the accuracy of the reports, and would only state that it had acted within the bounds of the law. Dow Chemical also refrained to comment on the matter.
The Indian authorities are well aware of the identity of the employee [who sabotaged the plant] and the nature of the evidence against him. Indian authorities refused to pursue this individual because they, as litigants, were not interested in proving that anyone other than Union Carbide was to blame for the tragedy.